山东青岛老来寿生物实验室色谱仪管道安装产品概述：

山东青岛老来寿生物实验室色谱仪管道安装集中供气系统作为气体储存、调压、输送及供应具有以下几个优点：一是集中供气系统将气源（钢瓶）集中在气瓶储存间，采用管路系统将气送到所需的工作地点，再将供气终端进行分流。因此工作地点看不到气瓶，显得规范、整洁。二是结构紧凑、安装方便、操作简单；三是集中供气系统更容易进行监控。因此采用集中供气系统进行供气更安全、更规范、更可靠。科望达主要提供氧气、氢气、氦气、氮气、乙炔、压缩空气等气体的集中供气系统设计及管路系统安装。

一、山东青岛老来寿生物实验室色谱仪管道安装技术要求

1、气瓶间

①气瓶间应采用300mm以上钢筋混凝土防爆墙，遮阳防晒，并安装防爆门，泄露窗。

②室内地面应有防火花、防静电措施；室内电气设备应具备防爆功能。

③通风良好，室内应安装排气扇。

④可燃气体钢瓶（氢气、乙炔）与助燃气体（氧气）应隔开放置。

⑤气瓶间要设置报警系统

2、工作间

①所有管道要统筹规划、集中布置、方便安装、便于操作、检修方便。

②所有工艺管道要设置切断阀，并根据需要设置压力表、温度计、流量计、过滤器和减压阀，阀门和仪表要设置在便于观察和检修的地方。

③可燃气体管道要沿墙明线铺设，方便安装和检修。

④使用钢瓶气管道的设备台应离墙布置，且留出不小于600mm的检修空间。

⑤氢气管道应采用焊接连接，不能采用螺纹连接和使用闸阀。

⑥供气系统采用二级减压方式进行供气，气体由15Mpa减到1.5Mpa后再输入到各实验室。

二、用材

1、管道、球阀、三通和卡套均采用316L不锈钢，高压软管为不锈钢波纹管，在高压软管的进气端配置单向阀，防止更换气瓶时，软管内的气体外泄，又可防止外界的空气混入气路中，影响气体纯度。

2、管道系统：所有气体管道均采用B*别316L不锈钢管，在管路上有过滤杂质和水分的装置。

3、管道的连接：汇排流、终端均采用卡套连接，便于减压器和阀门的维护管理。

4、终端：在每台仪器之前，配置截止阀和二级减压器，截止阀控制每个气路的开启和关闭，减压器用于显示和调整每个终端的压力。

5、气体管道每间隔1.5米采用管码支架固定。

6、整个气路安装完毕后，对整个系统做压力测试，压力24小时后无下降视为合格。